Research Article
Chemical, In-vitro Protein Digestibility, Minerals and Amino Acids Composition of Edible Peanut Seeds (Arachis hypogaea L.)
Department of Food Technology, Nyala Technological College, Nyala, Southern Darfur State, Sudan
INTRODUCTION
Peanut (Arachis hypogaea L.) is the third important oil seed crop of the world in production after soybean and cotton. In Sudan, the crop is cultivated in the traditional rainfed and under irrigation with an average total production of about 543.9 thousand metric tons. In the seventies, peanut was one of the most exported crops in the Sudan and during that period; Sudan was the second exporting country of peanut after the United States of America. It was exporting about 22% of the total world export and the annual revenue exceeded one hundred million dollars. Since the beginning of the eighties, the export of peanuts started to decline to less than one million dollars. Many factors were behind the deterioration and instability in the peanut export; among them, a reduction in peanut production and increasing of local consumption1. Peanuts are a rich source of protein, prior to 1990 the protein efficiency ratio method of protein evaluation considered peanut protein along with soy protein as an incomplete protein, containing relatively low amounts of essential amino acids, cystine and methionine but high in lysine and it was advised to be sure that a diet with peanuts as a stable also include complementary food such as whole grains like corn and wheat, which are adequate in methionine but limited by lysine2. Amino acid profile of peanut is in many respects inferior to the profile of soybean. Comparatively, the protein content of peanut is only about 70% of that of soybean. Peanuts are a reasonable source of dietary minerals especially potassium, phosphorus and magnesium. However, they are poor source of fat soluble vitamins like A, D and K2. Peanut oil is an excellent source of mono-and polyunsaturated fatty acids, exceeding the levels of these fatty acids in soybean and corn oil, but significantly lowers than in sunflower and safflower oil2. This study aimed to investigate the chemical, in-vitro protein digestibility, minerals and amino acids composition of edible peanut seeds grown under rainfed area of Darfur region.
MATERIALS AND METHODS
Material: The raw peanut seeds were obtained from Grieda, the most important rainfed area for oil seed crop production in Southern Darfur State, Sudan, during 2011/2012 season. The raw peanut seeds were cleaned and kept at room temperature (32°C) for further analysis.
Proximate analysis: The proximate analysis of raw peanut in term of moisture, ash and crude fat were determined in triplicate according to the AOAC3 method. Crude protein was calculated as N%x6.25 according to the AOAC4. Crude fiber was conducted by using acid/alkali digestion method according to the AOCS5. Total carbohydrates content was calculated by subtracting the previous components from 100.
In-vitro protein digestibility: In-vitro protein digestibility of raw peanut was determined according to the three-enzyme method as described by Hsu et al. and satterlee et al. 6,7 in which a multi-enzyme solution of (1.6 mg trypsin, 3.1 mg chymotrypsin and 1.3 mg peptidase per milliliter) was used in the determination.
Mineral contents: The minerals were determined by the dry-ashing method as described by Pearson8. Half a gram of raw peanut was weighed into a crucible and ashed in a muffle furnace at 600°C for 4 h. the ash was cooled and dissolved in dilute HCl (HCl: distilled water 1:3, v/v) and a few drops of concentrated nitric acid was added. The crucible was kept on a hot sand bath and boiled. The content was allowed to cool and transferred to 50 mL volumetric flask and the volume made up to the 50 mL mark with distilled water. Zinc and Ferrous were determined using a GBC 908 Atomic Absorption Spectrophotometer. Phosphorus was determined by the ammonium molybdate-ammonium vandate method. Calcium was determined by the titration Chapman and Pratt9. Sodium was determined using a Corning 410 flame photometer.
Amino acid analysis: Amino acids contents of raw peanut were measured on hydrolysates using amino acid analyzer (Sykam-S7130) based on high performance liquid chromatography technique. The peanut hydrolysates were prepared as described by Moor and Stein10. Two hundred milligrams of peanut were taken in hydrolysis tube. Then 5 mL 6N HCl were added to peanut into the tube, evacuated, tightly closed and incubated for 24 h at 110°C. After incubation period, the solution was filtered and 200 mL of the filtrate were evaporated to dryness at 140°C for an hour. The dried hydrolysate was diluted with one milliliter of 0.12 N, pH 2.2 citrate buffers, the same as the amino acid standards (amino acid standards H; Pierce Inc., Rockford; IL, USA). Aliquot of 150 μL of sample hydrolysate was injected in a cation separation column at 130°C. Ninhydrin solution and an eluent buffer (the buffer system contained solvent A, pH 3.45 and solvent B, pH 10.85) were delivered simultaneously into a high temperature reactor coil (16 m length) at a flow rate of 0.7 mL min1. The buffer/ninhydrin mixture was heated in the reactor at 130°C for 2 min to accelerate chemical reaction of amino acids with ninhydrine. The products of the reaction mixture were detected at wavelengths of 570 and 440 nm on a dual channel photometer. The amino acids composition was calculated from the areas of standards obtained from the integrator and expressed as percentages.
RESULTS AND DISCUSSIN
As shown in Table 1, moisture content of raw peanut was (5.9±0.01%). The result is agreement with the (5.8, 5.7 and 6.0±0.16%) reported by Atasie et al. Boutros and Abdualrahman11,12,13, respectively. The content of crude protein (28.97±0.03%) is within the range of (20-50%) reported by Nwokolo2 and higher than (26.7%) and (27.93±0.03%) determined by Boutros and Abdualrahman12,13, respectively. Ash content of peanut was (3.64±0.01%). This data is slightly lower than (3.8%) determined by Atasie et al.11 and higher than (2.3%) and (2.66±0.04%) reported by Boutros and Abdualrahman12,13, respectively. On the other hand, fat content of raw peanut (47.94±0.01%) is higher than (47.0%) and (47.34±0.11%) reported by Atasie et al. and Abdualrahman11,13 and lower than (49.2%) stated by Boutros12. The crude fiber content (3.17±0.02%) is higher than (2.12±0.07%) determined by Abdualrahman13 and lower than (3.70%) reported by Atasie et al.11. Total carbohydrate content of raw peanut was (10.38±0.01%). This result is much higher than (1.81%) determined by Atasie et al.11 and lower than (14.6%) and (19.95±0.18%) found by Boutros and Abdualrahman12,13, respectively. On the other hand, the in-vitro protein digestibility was (92.65±0.02%). This value is higher than (91.61±0.02%) reported by Abdualrahman13. However,14 reported a value of 93.06±0.042% for peanut in-vitro protein digestibility.
Table 2 showed that, sodium content of raw peanut was (2.10±0.03 mg 100 g1). It can be indicated that, this result is close agreement with the (2.0 mg 100 g1) reported by Woodroof15 and lower than the range of (19-48 mg 100 g1) reported by Yaw et al.16. The calcium content was (59±0.01 mg 100 g1). This result is agreement with range of (44-134 mg 100 g1) found by Yaw et al.16, higher than (57 mg 100 g1) reported by Boutros12 and lower than (60.0 mg 100 g1) indicated by Woodroof15. Phosphorus content of raw peanut was (254.5±0.01 mg 100 g1). This result is exceeded the value of (216 mg 100 g1) determined by Boutros12 and lower than (430 mg 100 g1) found by Woodroof15. The iron content was (2.3±0.03 mg 100 g1). This result is agreement with range of (0.20-3.70 mg 100 g1) reported by Yaw et al.16, close similar to (2.4 mg 100 g1) determined by Boutros12 and lower than (2.5 mg 100 g1) conducted by Woodroof15.
It can be observed that zinc content of raw peanut was (3.7±0.02). This result is agreement with the range of (0-6.5 mg 100 g1) determined by Yaw et al.16 and higher than (3.5 mg 100 g1) reported by Woodroof15.
From Table 3, it can be observed that glutamic acid and aspartic acid were the major amino acids (19.68 and 10.07 g 100 g1 protein), respectively in raw peanut. These results are slightly lower than (19.88 and 10.10 g 100 g1 protein), respectively reported by Abdualrahman13 and higher than (9.19 and 9.50 g 100 g1 protein), respectively found by Yagoub and Ahmed18 for peanut seed cake. Methionine content of raw peanut was (1.01 g 100 g1 protein). This result is higher than (0.91 g 100 g1 protein) reported by Abdualrahman13 and (0.60 g 100 g1 protein) reported by Yagoub and Ahmed18 for peanut seed cake. The content of cystine was (1.00 g 100 g1 protein) is higher than (0.96 g 100 g1 protein) determined by Abdualrahman13. From Table 3, it can be observed that glycine, alanine and valine contents of peanut were (4.44, 4.55 and 5.17 g 100 g1 protein), respectively. These results are lower than (4.79, 5.89 and 6.29 g 100 g1 protein), respectively reported by Yagoub and Ahmed18 for peanut seeds cake. Threonine and lysine (3.17 and 3.82 g 100 g1 protein), respectively are the limiting essential amino acid in raw peanut. Theronine content (3.17 g 100 g1 protein) is higher than (3.03 g 100 g1 protein) stated by Abdualrahman13 and (2.94 g 100 g1 protein) reported by Yagoub and Ahmed18 for peanut seed cake. Lysine content of raw peanut was (3.82 g 100 g1 protein). This result is close agreement with the (3.85 g 100 g1 protein) found by Yagoub and Ahmed18 for peanut seed cake. However,13 reported that lysine content of raw peanut was (3.79 g 100 g1 protein). Phenylalanine and leucine contents of peanut (6.10 and 7.31 g 100 g1 protein) are slightly higher than (6.07 and 7.27 g 100 g1 protein) reported by Abdualrahman13. However,18 reported that phenylalanine and tyrosine and leucine contents of peanut seed cake were (11.81 and 8.63 g 100 g1 protein), respectively. In addition to that, isoleucine content of raw peanut (4.22 g 100 g1 protein) is agreement with the (4.23 g 100 g1 protein) reported by Abdualrahman13 and lower than (5.12 g 100 g1 protein) determined by Yagoub and Ahmed18 for peanut seed cake. From Table 3, the amino acids results revealed that peanut was superior with respect to phenylalanine, leucine, isoleucine and valine when comparable to those of FAO reference pattern17. On the other hand, arginine content of peanut (13.31 g 100 g1 protein) is similar to (13.31 g 100 g1 protein) determined by Abdualrahman13 and lower than (15.09 g 100 g1 protein) reported by Yagoub and Ahmed18 for peanut seed cake. However,19 reported that, women consuming the arginine plus vitamins combination had a significantly reduced risk (12.7%) of developing pre-eclampsia compared to the vitamin-only group (22.5%) and the placebo group (30.1%). Total essential amino acid of raw peanut (33.73 g 100 g1 protein) is lower than (36.00 g 100 g1 protein) recommended by FAO/WHO17.
CONCLUSION
From the previous results it can be revealed that, Griedas peanut had good nutritive values in term of crude protein, fat, in-vitro protein digestibility, calcium, phosphorus, iron and zinc. The amino acids analysis revealed that peanut was superior with respect to phenylalanine, leucine, isoleucine and valine when comparable to those of FAO reference pattern.