Muhammad Hanif
Department of Agricultural Mechanization, Faculty of Crop Production Sciences, University of Agriculture, Peshawar, Pakistan
Masood Ur Rahman
Department of Agricultural Mechanization, Faculty of Crop Production Sciences, University of Agriculture, Peshawar, Pakistan
Muhammad Amin
Department of Agricultural Mechanization, Faculty of Crop Production Sciences, University of Agriculture, Peshawar, Pakistan
Mansoor Khan Khattak
Department of Agricultural Mechanization, Faculty of Crop Production Sciences, University of Agriculture, Peshawar, Pakistan
Muhammad Ramzan
Department of Agricultural Mechanization, Faculty of Crop Production Sciences, University of Agriculture, Peshawar, Pakistan
Subhan Ud Din
Department of Agricultural Mechanization, Faculty of Crop Production Sciences, University of Agriculture, Peshawar, Pakistan
Khanzeb Khan
Department of Agricultural Mechanization, Faculty of Crop Production Sciences, University of Agriculture, Peshawar, Pakistan
ABSTRACT
Solar drying of fruits, vegetables and grains is the oldest processing technique used for food preservation. In this research a flat plate solar air heater having an efficiency of 20% was used for drying onion flakes. The solar air heater assembly provides a temperature in the range of 40-50°C and humidity 10-30% in each day of drying period to the drying section. The drying section provides a total of 6 hours period per day as a suitable range for onions drying. Onions were dried and drying curves were developed for the drying kinetics of onions. The initial moisture in onions was 93% which was reduced to 5%. The moisture loss curve shows that onions lost 11% in each hour at an average. The drying curves of drying rate shows that the average drying rate of onions was 0.30 gH2O. gDM/h. Five published models (Newton, Page, Modified Page, Two-term expo and Wang) were tested to find relationship of drying curves with drying time. Among the five models Two-term expo model was the best describing drying kinetics on onions with R2 value 0.974 and Root Mean Square Error 0.447 for moisture lost and 0.953 and 0.451 for drying rate. It was concluded that flat plate solar air heater dries onions in short period of time. The quality of onions dried by a flat plate solar air heater may be better than open sun drying system. Among the five models Two-term expo model was the best describing drying kinetics on onions.
PDF References
How to cite this article
Muhammad Hanif, Masood Ur Rahman, Muhammad Amin, Mansoor Khan Khattak, Muhammad Ramzan, Subhan Ud Din and Khanzeb Khan, 2013. Convective Drying and Mathematical Modeling of Onions Dried Using a Flat Plate Solar Air Heater. Pakistan Journal of Nutrition, 12: 1003-1007.
DOI: 10.3923/pjn.2013.1003.1007
URL: https://scialert.net/abstract/?doi=pjn.2013.1003.1007
DOI: 10.3923/pjn.2013.1003.1007
URL: https://scialert.net/abstract/?doi=pjn.2013.1003.1007
REFERENCES
- Ahmad, F., N.R. Reza, M.H. Ruslan, M.Y. Othman and K. Sopian, 2012. Drying kinetics studies of onion (Allium cepa L.). J. Adv. Environ. Comp. Chem. Bio. Sci., 10: 113-117.
Direct Link - Altfeld, K., W. Leiner and M. Fiebig, 1988. Second law optimization of flat-plate solar air heaters. Part 2: Results of optimization and analysis of sensibility to variations of operating conditions. Solar Energy, 41: 309-317.
CrossRefDirect Link - Patil, M.M., S.B. Kalse and S.K. Jain, 2012. OSMO-convective drying of onion slices. Res. J. Recent Sci., 1: 51-59.
Direct Link - Demir, V., T. Gunhan and A.K. Yagcioglu, 2007. Mathematical modelling of convection drying of green table olives. Biosyst. Eng., 98: 47-53.
CrossRefDirect Link - Haghi, A.K., 2001. A mathematical model of the drying process. Acta Polytechnica, 41: 20-22.
Direct Link - Hanif, M., M. Ramzan and M. Aamir, 2012. Drying of grapes using a dish type solar air heater. J. Agric. Res., 50: 423-432.
Direct Link - Kadam, D.M., D.D. Nangare, R. Singh and S. Kumar, 2008. Low-cost greenhouse technology for drying onion (Allium cepa L.). J. Food Process Eng., 34: 67-82.
CrossRefDirect Link - Kumar, D.G.P., H.U. Hebbar, D. Sukumar and M.N. Ramesh, 2005. Infrared and hot-air drying of onions. J. Food Process. Preserv., 29: 132-150.
CrossRefDirect Link - Doymaz, I., 2012. Evaluation of some thin-layer drying models of persimmon slices (Diospyros kaki L.). Energy Conserv. Manage., 56: 199-205.
CrossRefDirect Link - Hii, C.L., C.L. Law and M.Cloke, 2008. Modeling of thin layer drying kinetics of cocoa beans during artificial and natural drying. J. Eng. Sci. Technol., 3: 1-10.
Direct Link - Wang, Z., J. Sun, X. Liao, F. Chen, G. Zhao, J. Wu and X. Hu, 2007. Mathematical modeling on hot air drying of thin layer apple pomace. Food Res. Int., 40: 39-46.
CrossRef